Influence of Selected Operating Parameters on Fungal Biomass Production in Corn-Ethanol Wastewater
Publication: Journal of Environmental Engineering
Volume 135, Issue 11
Abstract
Wastewater from a corn wet-milling ethanol plant was treated with Rhizopus microsporus mold in a continuous biofilm reactor (attached growth system). Plastic composite support tubes, composed of 50% (w/w) polypropylene and 50% (w/w) agricultural products were used as support media. The effects of operating pH (3.5, 4.0, and 4.5) and hydraulic retention times (HRTs) (5.0, 3.75, 2.5, and 1.25 h) on fungal growth, chemical oxygen demand (COD) removal and unwanted bacterial growth were evaluated under nonaseptic conditions. COD removal and biomass production were highest at pH 4.0 with lowest bacterial competition. Maximum COD removal of up to 80% was achieved at a 5.0 h HRT with a biomass yield of 0.44 g volatile suspended solids per g COD removed. A higher biomass yield was achieved at a shorter HRT of 2.5 h due to increased substrate availability; however, the biofilm was more sensitive to changes in wastewater composition. A HRT of 3.5–4 h was considered optimal in achieving organic removal and fungal biomass production. Significant loss of fungal biomass due to washout occurred at a 1.5 h HRT. Undesirable bacterial populations as a fraction of total biomass decreased with reducing HRT, excluding the 1.25 h HRT. Reductions in COD removal and biomass production were observed with decreases in aeration rate (1.0–0.25 L/min or 0.8–0.2 vvm (air volume per reactor working volume per minute). The recovered fungal biomass was found to contain protein of up to 40% (dry mass basis), which could serve as a source of high-value animal feed.
Get full access to this article
View all available purchase options and get full access to this article.
Acknowledgments
This material is based upon the work supported by the Cooperative State Research, Education, and Extension Service, U.S. Department of Agriculture (USDA) through the Iowa Biotechnology Byproducts Consortium (BBC), Archer Daniels Midland (ADM), Procter and Gamble (P&G), and the Iowa Agriculture and Home Economics Experiment Station. The work also represents part of the requirements for a Ph.D. in Civil Engineering (Environmental Engineering) at Iowa State University. The advice and encouragement of Dr. Jim Foster of ADM is much appreciated. The writers appreciate the technical support of Dr. John K. Strohl and Ms. Carol A. Ziel of the ISU Fermentation Facility, and the Center for Crops Utilization Research.
References
Ahmad, M. N., Holland, C. R., and McKay, G. (1994). “Mass transfer studies in batch fermentation: Mixing characteristics.” J. Food Eng., 23(2), 145–158.
American Public Health Association, American Water Works Association, and Water Environment Federation (APHA/AWWA/WEF). (1998). Standard methods for the examination of water and wastewater, Washington, D.C.
Assas, N., Marouani, L., and Hamdi, M. (2000). “Scale down and optimization of olive mill wastewater decolorization by Geotrichum candidum.” Bioprocess Eng., 22(6), 503–507.
Association of Official Analytical Chemists (AOAC). (1995). Official methods of analysis, Arlington, Va.
Barbesgaard, P., Heldt-Hansen, H. P., and Diterichsen, B. (1992). “On the safety of Aspergillus oryzae: A review.” Appl. Microbiol. Biotechnol., 36(5), 569–572.
Barker, T. W., and Worgan, J. T. (1981). “The application of air-lift fermentors to the cultivation of filamentous fungi.” Appl. Microbiol. Biotechnol., 13(2), 77–83.
Bischof, F., Höfken, M., and Durst, F. (1996). “Design and construction of aeration systems for optimum operation of large wastewater treatment plants.” Water Sci. Technol., 33(12), 189–198.
Canales, A., Pareilleux, A., Rols, J. L., Goma, G., and Huyard, A. (1994). “Decreased sludge production strategy for domestic treatment.” Water Sci. Technol., 30(8), 97–106.
Carlsen, M., Spohr, A. B., Nielsen, J., and Villadsen, J. (1996). “Morphology and physiology of an -amylase producing strain of Aspergillus oryzae during the batch cultivations.” Biotechnol. Bioeng., 49(3), 266–276.
Chen, L. M., and Chai, L. H. (2005). “Mathematical model and mechanisms for biofilm wastewater treatment systems.” World J. Microbiol. Biotechnol., 21(8–9), 1455–1460.
Christensen, T., et al. (1988). “High level expression of recombinant genes in Aspergillus oryzae.” Biotechnology (N.Y.), 6(12), 1419–1422.
Cooke, R. C., and Whipps, J. M. (1993). Ecophysiology of fungi, Blackwell, Oxford, U.K.
Cooke, W. B. (1976). “Fungi in sewage.” Recent advances in aquatic mycology, E. B. G. Jones, ed., Elek Science, London.
Cotton, J. C., Pometto, A. L., III, and Gvozdenovic, J. (2001). “Continuous lactic acid fermentation using a plastic composite support biofilm reactor.” Appl. Microbiol. Biotechnol., 57(5–6), 626–630.
Crestini, C., Kovac, B., and Giovannozzi-Sermanni, G. (1996). “Production and isolation of chitosan by submerged and solid-state fermentation from Lentinus edodes.” Biotechnol. Bioeng., 50(2), 207–210.
Curtis, E. J. C. (1969). “Sewage fungus: Its nature and effects.” Water Res., 3(5), 289–311.
Demirci, A., and Pometto, A. L., III. (1995). “Repeated-batch fermentation in biofilm reactors with plastic composite supports for lactic acid production.” Appl. Microbiol. Biotechnol., 43(4), 585–589.
Dempsey, M. J. (1994). “Biofilms and fluidized bed fermentation.” Int. Biodeter. Biodegrad., 34(3–4), 237–244.
Dubois, M., Gilles, K. A., Hamilton, J. K., Rebers, P. A., and Smith, F. (1956). “Colorimetric method for determination of sugars and related substances.” Anal. Chem., 28(3), 350–356.
Finkelstein, D. B., and Ball, C. (1992). Biotechnology of filamentous fungi: Technology and products, Butterworth-Heinemann, Stoneham, Mass.
Graham, D. C. W., Steinkraus, K. H., and Hackler, L. R. (1976). “Factors affecting production of mold mycelium and protein in synthetic media.” Appl. Environ. Microbiol., 32(3), 381–387.
Harder, W., and Kuenen, J. G. (1977). “Microbial selection in continuous culture.” J. Appl. Bacteriol., 43(1), 1–24.
Hiremath, A. B., Nimbargi, P. M., and Jayaraj, Y. M. (1985). “Domestic sewage treatment by fungi and biomass production.” Environ. Ecol., 3(44), 568–571.
Huang, L. P., Jin, B., Lant, P., and Zhou, J. (2003). “Biotechnological production of lactic acid integrated with potato wastewater treatment by Rhizopus arrhizus.” J. Chem. Technol. Biotechnol., 78(8), 899–906.
Huge-Jensen, B., Andreasen, F., Christensen, T., Christensen, M., Thim, L., and Boel, E. (1989). “Rhizomucor miehei triglyceride lipase is processed and secreted from transformed Aspergillus oryzae.” Lipids, 24(9), 781–785.
Jaouani, A., Guillén, F., Penninckx, M. J., Martinez, A. T., and Martinez, M. J. (2005). “Role of Pycnoporus coccineus laccase in the degradation of aromatic compounds in olive oil mill wastewater.” Enzyme Microb. Technol., 36(4), 478–486.
Jaouani, A., Sayadi, S., Vanthournhout, M., and Penninckx, M. J. (2003). “Potent fungi for decolorization of olive oil mill wastewaters.” Enzyme Microb. Technol., 33(6), 802–809.
Jasti, N., Khanal, S. K., Pometto, A. L., III, and van Leeuwen, J. (2008). “Converting corn wet-milling effluent into high-value fungal biomass in a biofilm reactor.” Biotechnol. Bioeng., 101(6), 1223–1233.
Jin, B., Tin, P., Ma, Y., and Zhao, L. (2005). “Production of lactic acid and fungal biomass by Rhizopus fungi from food processing waste streams.” J. Ind. Microbiol. Biotechnol., 32(11–12), 678–686.
Jin, B., van Leeuwen, J., Patel, B., Doelle, H. W., and Yu, Q. (1999a). “Production of fungal protein and glucoamylase by Rhizopus oligosporus from starch processing wastewater.” Process Biochem., 34(1), 59–65.
Jin, B., van Leeuwen, J., Patel, B., and Yu, Q. (1998). “Utilization of starch processing wastewater for production of microbial biomass protein and fungal -amylase by Aspergillus oryzae.” Bioresour. Technol., 66(3), 201–206.
Jin, B., van Leeuwen, J., Patel, B., and Yu, Q. (1999b). “Mycelial morphology and fungal protein production from starch processing wastewater in submerged cultures of Aspergillus oryzae.” Process Biochem. (Oxford, U.K.), 34(4), 335–340.
Jin, B., Yu, Q., and van Leeuwen, J. (2001). “A bioprocessing mode for simultaneous fungal biomass protein production and wastewater treatment using an external air-lift bioreactor.” J. Chem. Technol. Biotechnol., 76(10), 1041–1048.
Lowry, O. H., Rosebrough, N. J., Farr, A. L., and Randall, R. J. (1951). “Protein measurement with the Folin phenol reagent.” J. Biol. Chem., 193(1), 265–275.
Martins, A. M. P., Heijnen, J. J., and van Loosdrecht, M. C. M. (2003). “Effect of dissolved oxygen concentration on sludge settleability.” Appl. Microbiol. Biotechnol., 62(5–6), 586–593.
Medwid, R. D., and Grant, D. W. (1984). “Germination of Rhizopus oligosporus sporangiospores.” Appl. Microbiol. Biotechnol., 48(6), 1067–1071.
Metcalf and Eddy. (2003). Wastewater engineering: Treatment and reuse, 4th Ed., McGraw-Hill, New York.
Metz, B., and Kossen, N. W. F. (1977). “The growth of molds in the form of pellets—A literature review.” Biotechnol. Bioeng., 19(6), 781–799.
Mikami, Y., Gregory, K. F., Levadoux, W. L., Balagopalan, C., and Whitwill, S. T. (1982). “Factors affecting yield and safety of protein production from cassava by Cephalosporim eichhorniae.” Appl. Environ. Microbiol., 43(2), 403–411.
Mishra, B. K., Arora, A., and Lata. (2004). “Optimization of a biological process for treating potato chips industry wastewater using a mixed culture of Aspergillus foetidus and Aspergillus niger.” Bioresour. Technol., 94(1), 9–12.
Nicolella, C., van Loosdrecht, M. C. M., and Heijnen, S. J. (2000). “Particle-based biofilm reactor technology.” Trends Biotechnol., 18(7), 312–320.
Ong, S. L., Liu, Y., Lee, L. Y., Hu, J. Y., and Ng, W. J. (2004). “A novel high capacity biofilm reactor system for treatment of domestic sewage.” Water, Air, Soil Pollut., 157(1–4), 245–256.
Oshoma, C. E., and Ikenebomeh, M. J. (2005). ““Production of Aspergillus niger biomass from rice bran.” ak.” J. Nutr., 4(1), 32–36.
Pan, S., Tay, J. H., He, Y. X., and Tay, S. T. L. (2004). “The effect of hydraulic retention time on the stability of aerobically grown microbial granules.” Lett. Appl. Microbiol., 38(2), 158–163.
Patel, A., Nakhla, G., and Zhu, J. (2005). “Detachment of multi species biofilm in circulating fluidized bed bioreactor.” Biotechnol. Bioeng., 92(4), 427–437.
Pochanavanich, P., and Suntornsuk, W. (2002). “‘Fungal chitosan production and its characterization’ ett.” Appl. Microbiol., 35(1), 17–21.
Pretorius, W. A. (1987). “A conceptual basis for microbial selection in biological wastewater treatment.” Water Res., 21(8), 891–894.
Pringle, J. H., and Fletcher, M. (1983). “Influence of substratum wettability on attachment of fresh bacteria to solid surface.” Appl. Environ. Microbiol., 45(3), 811–817.
Ravinder, R., Rao, L. V., and Ravindra, P. (2003). “Studies on Aspergillus oryzae mutants for the production of single cell protein from deoiled rice bran.” Food Technol. Biotechnol., 41(3), 243–246.
Robles, A., Lucas, R., de Cienfuegos, A. G., and Gálvez, A. (2000). “Biomass production and detoxification of wastewaters from the olive oil industry by strains of Penicillium isolated from wastewater disposal ponds.” Bioresour. Technol., 74(3), 217–221.
Sankaran, S., Khanal, S. K., Pometto, A. L., III, and van Leeuwen, J. (2008). “Ozone as a selective disinfectant for nonaseptic fungal cultivation on corn-processing wastewater.” Bioresour. Technol., 99(17), 8265–8273.
Smits, T. H. M., Wick, L. Y., Harms, H., and Keel, C. (2003). “Characterization of the surface hydrophobicity of filamentous fungi.” Environ. Microbiol., 5(2), 85–91.
Stevens, C. A., and Gregory, K. F. (1987). “Production of microbial biomass protein from potato process waste by Cephalosporim eichhorniae.” Appl. Environ. Microbiol., 53(2), 284–291.
Taber, A. W. (1976). “Wastewater microbiology.” Annu. Rev. Microbiol., 30, 263–277.
Thanh, N. C., and Simard, R. E. (1973). “Biological treatment of domestic sewage by fungi.” Mycopathol Mycol. Appl., 51(2), 223–232.
Thanh, N. V., and Nout, M. J. R. (2004). “Dormancy, activation and viability of Rhizopus oligosporus sporangiospores.” Int. J. Food Microbiol., 92(2), 171–179.
Tijhuis, L., Hijman, B., van Loosdrecht, M. C. M., and Heijnen, J. J. (1996). “Influence of detachment, substrate loading and reactor scale on the formation of biofilms in airlift reactors.” Appl. Microbiol. Biotechnol., 45(1–2), 7–17.
Truong, T., Miyata, N., and Iwahori, K. (2004). “Growth of Aspergillus oryzae during treatment of cassava starch processing wastewater with high content of suspended solids.” J. Biosci. Bioeng., 97(5), 329–335.
Tsuchiya, K., et al. (1992). “High level expression of the synthetic human gene lysozyme in Aspergillus oryzae.” Appl. Microbiol. Biotechnol., 38(1), 109–114.
United States Environmental Protection Agency (USEPA). (1999). “Biosolids generation, use, and disposal in the United States.” Rep. No. EPA530-R-99–009, Municipal and Industrial Solid Waste Division, Office of Solid Waste and Emergency Response, Washington, D.C.
Van der Westhuizen, T. H., and Pretorius, W. A. (1996). “Production of valuable products from organic waste streams.” Water Sci. Technol., 33(8), 31–38.
Van der Westhuizen, T. H., and Pretorius, W. A. (1998). “Use of filamentous fungi for the purification of industrial effluents.” WRC Report No. 535/l/98, Water Research Commission, Pretoria, South Africa.
Van Leeuwen, J., Hu, Z., Yi, T., and Pometto, A. L., III. (2002). “Use of micro-fungi for single cell protein production during food processing wastewater treatment.” Proc., 75th Annual Water Environment Federation (WEF) Conf., 485–493.
Van Leeuwen, J., Hu, Z., Yi, T., Pometto, A. L., III, and Jin, B. (2003). “Kinetic model for selective cultivation of microfungi in a microscreen process for food processing wastewater treatment and biomass production.” Acta Biotechnol., 23(2–3), 289–300.
Vanhooren, H. (2001). “Modelling for optimization of biofilm wastewater treatment processes: A complexity compromise.” Ph.D. thesis, Faculty of Agricultural and Applied Biological Sciences, Ghent Univ., Belgium.
Villaseñor, J. C., van Loosdrecht, M. C. M., Picioreanu, C., and Heijnen, J. J. (2000). “Influence of different substrates on the formation of biofilms in a biofilm airlift suspension reactor.” Water Sci. Technol., 41(4–5), 323–330.
Ward, P. P., Lo, J., Duke, M., May, G. S., Headon, D. R., and Conneely, O. M. (1992). “Production of biologically active recombinant human lactoferrin in Aspergillus oryzae.” Nat. Biotechnol., 10(7), 784–789.
Yang, S. F., Liu, Q. S., Tay, J. H., and Liu, Y. (2004). “Growth kinetics of aerobic granules developed in sequencing batch reactors.” Lett. Appl. Microbiol., 38(2), 106–112.
Yokoi, H., Aratake, T., Nishio, S., Hirose, J., Hayashi, S., and Takasai, Y. (1998). “Chitosan production from Shochu distillery wastewater by funguses.” J. Ferment. Bioeng., 85(2), 246–249.
Information & Authors
Information
Published In
Copyright
© 2009 ASCE.
History
Received: Jun 15, 2008
Accepted: Apr 21, 2009
Published online: May 30, 2009
Published in print: Nov 2009
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.