Flexural Behavior of Preloaded RC Slabs Strengthened with Prestressed CFRP Laminates
Publication: Journal of Composites for Construction
Volume 18, Issue 3
Abstract
Many studies performed on reinforced concrete (RC) members strengthened in flexure with externally bonded (EB) fiber-reinforced polymers (FRPs) have indicated quite low strengthening efficiency caused by debonding of the FRP from the concrete surface prior to the capacity of the FRP material being achieved. It should be emphasized that although flexural strengthening with FPR increases the load-bearing capacity of RC members, it has little effect on the serviceability limit state (i.e., cracking moment and deflections). Prestressing the EB FRP has been proposed as a method of increasing utilization of the FRP tensile strength and of improving the efficiency of strengthening in terms of serviceability limit states. An experimental research program consisting of three series of RC slabs with variations in the longitudinal steel reinforcement ratio, concrete strength, preloading level before strengthening, and adhesion between the CFRP laminates and the concrete is described. A practical and unique aspect of the program focuses on an analysis of the effect of preloading on the strengthening efficiency of RC slabs strengthened with prestressed carbon fiber-reinforced polymer (CFRP) laminates. Although the preloading is one of the most important parameters to be accounted for in the design of strengthening existing RC structures, this aspect has been investigated only rarely. Two levels of slabs preloading were considered: the slab self-weight acting alone and the self-weight plus an additional external load. The self-weight preloading level corresponded to 25 and 14% of the yield strength of nonstrengthened slabs in Series I and III, respectively. The higher preloading level, equal to 76% of the yield strength of the nonstrengthened slab, was chosen to approach the elastic limit of the slab behavior. Experimental tests yielded promising results for the ultimate and serviceability limit states of the strengthened slabs. The strengthening ratio, defined as the ratio of the difference between the ultimate load of the strengthened and nonstrengthened slabs to the ultimate load of the nonstrengthened slab, reached values in the range of 0.64–1.19. The influence of the tensile steel reinforcement ratio, adhesion between the prestressed CFRP laminate and concrete, and preloading level on the ultimate load carrying capacity following strengthening is discussed.
Get full access to this article
View all available purchase options and get full access to this article.
Acknowledgments
This study was carried out as part of the project, “Innovative resources and effective methods of safety improvement and durability of buildings and transport infrastructure in the sustainable development strategy,” (POIG.01.01.02-10-106/09) financed by the European Union from the European Fund of Regional Development based on the Operational Program of the Innovative Economy, which the authors wish to acknowledge.
References
Aram, M. R., Czaderski, C., and Motavalli, M. (2008). “Effects of gradually anchored prestressed CFRP strips bonded on prestressed concrete slabs.” J. Compos. Constr., 25–34.
Czaderski, C., and Motavalli, M. (2007). “40-year-old full-scale concrete bridge girder strengthened with prestressed CFRP plates anchored using gradient method.” Compos. Part B, 38(7–8), 878–886.
Czkwianianc, A., and Kaminska, M. E. (1993). Method of nonlinear analysis of one-dimensional reinforced concrete members, KILiW PAN IPPT, Warsaw, 36 (in Polish).
Deuring, M. (1993). “Verstärken von Stahlbeton mit gespannten Faserverbundwerkstoffen.” EMPA Dübendorf, Bericht Nr. 224, Switzerland (in German).
El-Hacha, R., Wight, R. G., and Green, M. F. (2003). “Innovative system for prestressing fiber-reinforced polymer sheets.” ACI Struct. J., 100(3), 305–313.
Kałuża, M., and Ajdukiewicz, A. (2008). “Comparison of behaviour of concrete beams with passive and active strengthening by means of CFRP strips.” Archit. Civil Eng. Environ., 1(2), 51–64.
Kim, Y., Wight, R., and Green, M. (2008a). “Flexural strengthening of RC beams with prestressed sheets: Using nonmetallic anchor system.” J. Compos. Constr., 44–52.
Kim, Y., Wight, R., and Green, M. (2008b). “Flexural strengthening of RC slabs with prestressed CFRP sheets: Development of nonmetallic anchor systems.” J. Compos. Constr., 35–43.
Kotynia, R. (2006). “Analysis of reinforced concrete beams strengthened with near surface mounted FRP reinforcement.” Arch. Civil Eng., 52(2), 305–317.
Kotynia, R., Baky, H. A., Neale, K. W., and Ebead, U. A. (2008). “Flexural strengthening of RC beams with externally bonded CFRP systems: Test results and 3-D nonlinear FE analysis.” J. Compos. Constr., 190–201.
Kotynia, R., and Kamińska, M. E. (2003). “Ductility and failure mode of RC beams strengthened for flexure with CFRPs.”, Dept. of Concrete Structures TUL, Poland.
Kotynia, R., Walendziak, R., Stoecklin, I., and Meier, U. (2011). “RC slabs strengthened with prestressed and gradually anchored cfrp strips under monotonic and cycling loading.” J. Compos. Constr., 168–180.
Meier, U. (1995). “Strengthening of structures using carbon fibre/epoxy composites.” Constr. Build. Mater., 9(6), 341–351.
Pellegrino, C., and Modena, C. (2009). “Flexural strengthening of real-scale RC and PRC beams with end-anchored pretensioned FRP laminates.” ACI Struct. J., 106(3), 319–328.
Stöcklin, I., and Meier, U. (2003). “Strengthening of concrete structures with prestressed and gradually anchored CFRP strips.” Proc., 6th Int. Symp. FRP Reinforcement for Concrete Structures, FRPRCS-6, K. H. Tan, ed., World Scientific, Singapore, 1321–1330.
Teng, J. G., Chen, J. F., Smith, S. T., and Lam, L. (2002). FRP strengthened RC structures, Wiley, Chichester, UK.
Trintafillou, T. C., Deskovic, N., and Deuring, M. (1992). “Strengthening of concrete structures with prestressed fiber reinforced sheets.” ACI Struct. J., 89(3), 235–244.
Wight, R. G., Green, M. F., and Erki, M.-A. (2001). “Prestressed FRP sheets for poststrengthening reinforced concrete slabs.” J. Compos. Constr., 214–220.
Young-Chan, Y., Ki-Sun, C., and JunHee, K. (2012). “An experimental investigation on flexural behavior of RC beams strengthened with prestressed CFRP strips using a durable anchorage system.” Compos. Part B, 43(8), 3026–3036.
Yu, P., Silva, P., and Nanni, A. (2008). “Flexural strength of reinforced concrete beams strengthened with prestressed carbon fiber-reinforced polimer sheets—part II.” ACI Struct. J., 105(1), 11–20.
Information & Authors
Information
Published In
Copyright
© 2013 American Society of Civil Engineers.
History
Received: Mar 19, 2013
Accepted: Jul 22, 2013
Published online: Jul 24, 2013
Discussion open until: Mar 30, 2014
Published in print: Jun 1, 2014
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.