Numerical Evaluation of Control Measures for Tunnel Deformation Induced by an Oversized Deep Excavation
Publication: Journal of Aerospace Engineering
Volume 31, Issue 6
Abstract
Deep excavations conducted close to tunnels will cause an adverse impact on tunnels, and countermeasures must be taken during the excavation to ensure the safety of the tunnels. However, the effectiveness of measures to control the vertical displacement of tunnels is still unclear, especially when a cut-and-cover tunnel is tied to a deep excavation. In this study, a three-dimensional (3D) numerical method is used to evaluate the effectiveness of control measures for excavation-induced tunnel deformations. Based on a recent case of a deep excavation in Shanghai, a quasi-three-dimensional numerical model considering the soil–structure interaction and fluid–solid coupling was built by the use of finite difference software, i.e., FLAC3D v5.0. Four countermeasures, i.e., zoned excavation with partition walls and cross walls, piles tied to the walls, soil reinforcement, and dewatering in the confined aquifer, were implemented in this model. The numerical model was validated by field data and the effectiveness of these measures was evaluated comprehensively. Results indicate that the zoned excavation can reduce the vertical displacement of the tunnel, while the cross wall will cause an adverse impact on restraining the tunnel heave. Installation of tie piles can decrease the uplift of tunnels, and the maximum tunnel heave decreases with the increase of the length of the tie piles. Soil improvement is the most effective countermeasure that can reduce the tunnel heave significantly. Dewatering in a confined aquifer can be adopted as a countermeasure to restrain the tunnel heave during excavation.
Get full access to this article
View all available purchase options and get full access to this article.
Acknowledgments
The financial support from the National Natural Science Foundation of China (NSFC Grant Nos. 41602283, 41330633, and 41727802) is gratefully acknowledged.
References
Chang, C. T., C. W. Sun, S. W. Duann, and R. N. Hwang. 2001. “Response of a Taipei Rapid Transit System (TRTS) tunnel to adjacent excavation.” Tunnelling Underground Space Technol. 16 (3): 151–158. https://doi.org/10.1016/S0886-7798(01)00049-9.
Chen, J. J., Y. F. Zhu, M. G. Li, and S. L. Wen. 2014. “Novel excavation and construction method of an underground highway tunnel above operating metro tunnels.” J. Aerosp. Eng. 28 (6): A4014003. https://doi.org/10.1061/(ASCE)AS.1943-5525.0000437.
Demeijer, O., J. J. Chen, M. G. Li, J. H. Wang, and C. J. Xu. 2018. “Influence of passively loaded piles on excavation-induced diaphragm wall displacements and ground settlements.” Int. J. Geomech. 18 (6): 04018052. https://doi.org/10.1061/(ASCE)GM.1943-5622.0001126.
Dolezalova, M. 2001. “Tunnel complex unloaded by a deep excavation.” Comput. Geotech. 28 (6–7): 469–493. https://doi.org/10.1016/S0266-352X(01)00005-2.
Dong, Y. P., H. Burd, G. Houlsby, and Y. M. Hou. 2014. “Advanced finite element analysis of a complex deep excavation case history in Shanghai.” Front. Struct. Civ. Eng. 8 (1): 93–100. https://doi.org/10.1007/s11709-014-0232-3.
Dong, Y. P., H. J. Burd, and G. T. Houlsby. 2015. “Finite-element analysis of a deep excavation case history.” Géotechnique 66 (1): 1–15. https://doi.org/10.1680/jgeot.14.P.234.
Finno, R. J., D. K. Atmatzidis, and S. B. Perkins. 1989. “Observed performance of a deep excavation in clay.” J. Geotech. Eng. 115 (8): 1045–1064. https://doi.org/10.1061/(ASCE)0733-9410(1989)115:8(1045).
Goh, A. T. C., F. Zhang, W. Zhang, Y. Zhang, and H. Liu. 2017. “A simple estimation model for 3D braced excavation wall deflection.” Comput. Geotech. 83: 106–113. https://doi.org/10.1016/j.compgeo.2016.10.022.
Guo, F., W. Gu, J. J. Tang, and M. H. Murong. 2013. “Research on deformation stability of soft rock slope under excavation based on FLAC3D.” Appl. Mech. Mater. 275–277: 290–294. https://doi.org/10.4028/www.scientific.net/AMM.275-277.290.
Han, L., G. L. Ye, J. J. Chen, X. H. Xia, and J. H. Wang. 2017. “Pressures on the lining of a large shield tunnel with a small overburden: A case study.” Tunnelling Underground Space Technol. 64: 1–9. https://doi.org/10.1016/j.tust.2017.01.008.
He, Z., Z. Peng, P. Cao, and H. Lin. 2009. “Numerical analysis for roof stability of double gob area after excavation by FLAC∼(3D).” J. Cent. South Univ. Technol. 40 (4): 1066–1071.
Hsieh, H. S., Y. C. Lu, and T. M. Lin. 2008. “Effects of joint details on the behavior of cross walls.” J. GeoEng. 3 (2): 55–60.
Hsieh, H. S., C. C. Wang, and C. Y. Ou. 2003. “Use of jet grouting to limit diaphragm wall displacement of a deep excavation.” J. Geotech. Geoenviron. Eng. 129 (2): 146–157. https://doi.org/10.1061/(ASCE)1090-0241(2003)129:2(146).
Hsieh, P. G., and C. Y. Ou. 2012. “Analysis of deep excavations in clay under the undrained and plane strain condition with small strain characteristics.” J. Chin. Inst. Eng. 35 (5): 601–616. https://doi.org/10.1080/02533839.2012.679115.
Hu, Z. F., Z. Q. Yue, J. Zhou, and L. G. Tham. 2003. “Design and construction of a deep excavation in soft soils adjacent to the Shanghai Metro tunnels.” Can. Geotech. J. 40 (5): 933–948. https://doi.org/10.1139/t03-041.
Huang, L. C., Z. S. Xu, and C. Y. Zhou. 2009. “Modeling and monitoring in a soft argillaceous shale tunnel.” Acta Geotech. 4 (4): 273–282. https://doi.org/10.1007/s11440-009-0100-9.
Huang, X., H. F. Schweiger, and H. W. Huang. 2013. “Influence of deep excavations on nearby existing tunnels.” Int. J. Geomech. 13 (2): 170–180. https://doi.org/10.1061/(ASCE)GM.1943-5622.0000188.
Itasca. 2014. FLAC3D. Fast Lagrangian analysis of continua in 3-dimensions. Minneapolis: Itasca.
Kuta, Y., M. Maruoka, M. Aoki, and E. Sato. 1994. “Application of the observational method to a deep basement excavated using the top-down method.” Geotechnique 44 (4): 655–664. https://doi.org/10.1680/geot.1994.44.4.655.
Li, M. G., J. J. Chen, J. H. Wang, and Y. F. Zhu. 2018. “Comparative study of construction methods for deep excavations above shield tunnels.” Tunnelling Underground Space Technol. 71: 329–339. https://doi.org/10.1016/j.tust.2017.09.014.
Li, M. G., J. J. Chen, A. J. Xu, and X. H. Xia. 2014. “Case study of innovative top-down construction method with channel-type excavation.” J. Constr. Eng. Manage. 140 (5): 05014003. https://doi.org/10.1061/(ASCE)CO.1943-7862.0000828.
Li, M. G., J. H. Wang, J. J. Chen, and Z. J. Zhang. 2017a. “Responses of a newly built metro line connected to deep excavations in soft clay.” J. Perform. Constr. Facil. 31 (6): 04017096. https://doi.org/10.1061/(ASCE)CF.1943-5509.0001091.
Li, M. G., Z. J. Zhang, J. J. Chen, J. H. Wang, and A. J. Xu. 2017b. “Zoned and staged construction of an underground complex in Shanghai soft clay.” Tunnelling Underground Space Technol. 67: 187–200. https://doi.org/10.1016/j.tust.2017.04.016.
Liu, G. B., P. Huang, J. W. Shi, and C. W. W. Ng. 2016. “Performance of a deep excavation and its effect on adjacent tunnels in Shanghai soft clay.” J. Perform. Constr. Facil. 30 (6): 04016041. https://doi.org/10.1061/(ASCE)CF.1943-5509.0000891.
Liu, H. L., P. Li, and J. Y. Liu. 2011. “Numerical investigation of underlying tunnel heave during a new tunnel construction.” Tunnelling Underground Space Technol. 26 (2): 276–283. https://doi.org/10.1016/j.tust.2010.10.002.
Long, M. 2001. “Database for retaining wall and ground movements due to deep excavations.” J. Geotech. Geoenviron. Eng. 127 (3): 203–224. https://doi.org/10.1061/(ASCE)1090-0241(2001)127:3(203).
Ng, C. W. W., J. W. Shi, and Y. Hong. 2013. “Three-dimensional centrifuge modelling of basement excavation effects on an existing tunnel in dry sand.” Can. Geotech. J. 50 (8): 874–888. https://doi.org/10.1139/cgj-2012-0423.
Ou, C. Y., P. G. Hsieh, and Y. L. Lin. 2011. “Performance of excavations with cross walls.” J. Geotech. Geoenviron. Eng. 137 (1): 94–104. https://doi.org/10.1061/(ASCE)GT.1943-5606.0000402.
Ou, C. Y., P. G. Hsieh, and Y. L. Lin. 2013. “A parametric study of wall deflections in deep excavations with the installation of cross walls.” Comput. Geotech. 50 (5): 55–65. https://doi.org/10.1016/j.compgeo.2012.12.009.
Ou, C. Y., Y. L. Lin, and P. G. Hsieh. 2006. “Case record of an excavation with cross walls and buttress walls.” J. GeoEng. 1 (2): 79–86. https://doi.org/10.6310/jog.2006.1(2).4.
Ou, C. Y., F. C. Teng, and I. W. Wang. 2008. “Analysis and design of partial ground improvement in deep excavations.” Comput. Geotech. 35 (4): 576–584. https://doi.org/10.1016/j.compgeo.2007.09.005.
Ou, C. Y., T. S. Wu, and H. S. Hsieh. 1996. “Analysis of deep excavation with column type of ground improvement in soft clay.” J. Geotech. Eng. 122 (9): 709–716. https://doi.org/10.1061/(ASCE)0733-9410(1996)122:9(709).
Sharma, J. S., A. M. Hefny, J. Zhao, and C. W. Chan. 2001. “Effect of large excavation on deformation of adjacent MRT tunnels.” Tunnelling Underground Space Technol. 16 (2): 93–98. https://doi.org/10.1016/S0886-7798(01)00033-5.
Shi, J. W., C. W. W. Ng, and Y. H. Chen. 2015. “Three-dimensional numerical parametric study of the influence of basement excavation on existing tunnel.” Comput. Geotech. 63: 146–158. https://doi.org/10.1016/j.compgeo.2014.09.002.
Tan, Y., X. Li, Z. Kang, J. Liu, and Y. Zhu. 2015. “Zoned excavation of an oversized pit close to an existing metro line in stiff clay: Case study.” J. Perform. Constr. Facil. 29 (6): 04014158. https://doi.org/10.1061/(ASCE)CF.1943-5509.0000652.
Wang, J. H., Z. H. Xu, and W. D. Wang. 2010. “Wall and ground movements due to deep excavations in Shanghai soft soils.” J. Geotech. Geoenviron. Eng. 136 (7): 985–994. https://doi.org/10.1061/(ASCE)GT.1943-5606.0000299.
Ye, G. L., T. Hashimoto, S. L. Shen, H. H. Zhu, and T. H. Bai. 2015. “Lessons learnt from unusual ground settlement during Double-O-Tube tunnelling in soft ground.” Tunnelling Underground Space Technol. 49: 79–91. https://doi.org/10.1016/j.tust.2015.04.008.
Zhang, J. F., J. J. Chen, J. H. Wang, and Y. F. Zhu. 2013. “Prediction of tunnel displacement induced by adjacent excavation in soft soil.” Tunnelling Underground Space Technol. 36 (2): 24–33. https://doi.org/10.1016/j.tust.2013.01.011.
Zhang, W., and A. T. C. Goh. 2012. “Reliability assessment on ultimate and serviceability limit states and determination of critical factor of safety for underground rock caverns.” Tunnelling Underground Space Technol. 32: 221–230. https://doi.org/10.1016/j.tust.2012.07.002.
Zhang, W., and A. T. C. Goh. 2016. “General behavior of braced excavation in Bukit Timah Granite residual soils: A case study.” Int. J. Geoeng. Case Histories 3 (3): 190–202. https://doi.org/10.4417/IJGCH-03-05-05.
Zheng, G., and S. W. Wei. 2008. “Numerical analyses of influence of overlying pit excavation on existing tunnels.” Supplement, J. Cent. South Univ. Technol. 15 (S2): 069–075. https://doi.org/10.1007/s11771-008-0438-4.
Zheng, G., X. Yang, H. Zhou, Y. Du, J. Sun, and X. Yu. 2018. “A simplified prediction method for evaluating tunnel displacement induced by laterally adjacent excavations.” Comput. Geotech. 95: 119–128. https://doi.org/10.1016/j.compgeo.2017.10.006.
Information & Authors
Information
Published In
Copyright
©2018 American Society of Civil Engineers.
History
Received: Jun 5, 2017
Accepted: Apr 2, 2018
Published online: Sep 6, 2018
Published in print: Nov 1, 2018
Discussion open until: Feb 6, 2019
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.