Design, Manufacturing, and Ground Testing of a Control-Moment Gyro for Agile Microsatellites
Publication: Journal of Aerospace Engineering
Volume 30, Issue 5
Abstract
A recently emerged driving requirement for microsatellites is a precise and fast attitude maneuvering capability. Agility enhances the operational efficiency of missions requiring a high level of retargeting ability, such as space station and satellite on-orbit servicing, formation flying, Earth monitoring, and space-based space debris observation and tracking. Three-axis stabilized microsatellites are mainly equipped with momentum wheels, barely meeting agility requirements. In this paper, the design and manufacturing of a cluster of four single-gimbal variable-speed control-moment gyros (SGCMGs), suitable for attitude control with high-agility capability of a 10–30 kg class microsatellite, is presented. The flywheel design is based on a brushless motor out-runner configuration, in which the motor magnets, embedded in the rotor, provide for the wheel inertia. This configuration has the advantage of providing a high inertia while minimizing cogging torque at low speed. The elimination of the wheel dummy mass provides a significant improvement in the system mass efficiency. In addition, this configuration allows using commercial off-the-shelf parts, eliminating the wheel-balancing procedure with evident jitter limitation and economic and development time benefits. A relevant feature is the electronics architecture based on a field-programmable gate array (FPGA) integrated circuit, chosen to improve power efficiency and provide a high level of reliability for the system. This can be assured by proper time and space redundancy for each low-level logic block of the design. The system performance in terms of provided torque and power consumption has been experimentally measured by using a ground-testing prototype mounted on a test bed, and the results are reported. The results confirm the effectiveness of the proposed actuator as an efficient solution for the attitude control of microsatellites, in terms of mass, volume, and power constraints.
Get full access to this article
View all available purchase options and get full access to this article.
References
Arena, L. (2014). “A small, low-cost and maintenance-free test-bed for agile satellite attitude control using momentum exchange devices.” Proc., 65th Int. Astronautical Congress, Toronto.
Branets, V. N., et al. (1988). “Development experience of the attitude control system using single-axis control moment gyros for long-term orbiting space stations.” Acta Astronaut., 18, 91–98.
Carpenter, M. D., and Peck, M. A. (2008). “Dynamics of a high-agility, low-power imaging payload.” IEEE Trans. Rob., 24(3), 666–675.
Chubb, W. B., Kennel, H. F., Rupp, C., and Seltzer, S. M. (1975). “Flight performance of Skylab attitude and pointing control system.” J. Spacecraft Rockets, 12(4), 200–227.
Clark, C., Worral, K., and Yavuzoğlu, E. (2010). “A control moment gyro for dynamic attitude control of small satellites.” Proc., 24th Annual AIAA/USU Conf. on Small Satellites, Technical Session XI: Mission Enabling Technologies 2.
Defendini, A., et al. (2003). “Control moment GYRO CMG 15-45 S: A compact CMG product for agile satellites in the one ton class.” Proc., 10th European Space Mechanisms and Tribology Symp., ESA Publications Division, Noordwijk, Netherlands, 27–31.
Ertan, H. B., and Yilmaz, K. (2011). “Choice of pole number of two-rotor axial-flux PM motor for control moment gyroscope.” Proc., 2011 Int. Aegean Conf. on Electrical Machines and Power Electronics and 2011 Electromotion Joint Conf., IEEE, New York, 620–625.
Gurrisi, C., et al. (2010). “Space station control moment gyroscope lesson learned.” Proc., 40th Aerospace Mechanisms Symp., NASA Kennedy Space Center, Cocoa Beach, FL, 161–175.
Kennel, H. F. (1970). “A control law for double-gimballed control moment gyros used for space vehicle attitude control.”, Huntsville, AL.
Kumaravelu, U. D., and Yakub, S. M. (2012). “Simulation of outer rotor permanent magnet brushless DC motor using finite element method for torque improvement.” Model. Simul. Eng., 2012, 6.
Lappas, V. J. (2004). “Design, analysis and in-orbit performance of the BILSAT-1 microsatellite twin control moment gyroscope experimental cluster.” AIAA Guidance, Navigation and Control Conf. and Exhibit, AIAA, Providence, RI.
Lappas, V. J., Steyn, W. H., and Underwood, C. I. (2002). “Attitude control for small satellites using control moment gyros.” Acta Astronaut., 51(1–9), 101–111.
Lappas, V. J., Steyn, W. H., and Underwood, C. I. (2005). “Design and testing of a control moment gyroscope cluster for small satellites.” J. Spacecraft Rockets, 42(4), 729–739.
Nishida, J., and Tsubuku, Y. (2007). “Tokyo tech’s technology demonstration satellite TSUBAME.” Proc., 21st Annual AIAA/USU Conf. on Small Satellites, Logan, UT.
Omagari, K., Fujihashi, K., and Matunaga, S. (2008). “CMG configuration and control for rapid attitude maneuver of small spacecraft.” Proc., 9th Int. Symp. on Artificial Intelligence, Robotics and Automation in Space, Los Angeles.
Pages, A., Lacombe, G., Marion, F., Brunotte, X., and Le Letty, R. (2008). “Upgrade of miniature outrunner brushless DC motors.” Proc., 11th Int. Conf. on New Actuators, Bremen, Germany, 681–683.
Raushenbakh, B. V., and Tokar, J. N. (1971). “Attitude control system of Molniya 1 communication satellite.” Automatica, 7(1), 7–13.
Roser, X., and Sghedoni, M. (1996). “Control moment gyroscopes (CMG’s) and their application in future scientific missions.” Proc., 3rd ESA Int. Conf., ESTEC, Noordwijk, Netherlands.
Sinclair, D., Grant, C. C., and Zee, R. E. (2007). “Enabling reaction wheel technology for high performance nanosatellite attitude control.” Proc., AIAA/USU Conf. on Small Satellites, Technical Session X: Advanced Technologies 1, SSC07-X-3, North Logan, UT.
Wie, B., Bailey, D., and Heiberg, C. (2002). “Rapid multitarget acquisition and pointing of agile spacecraft.” J. Guidance Control Dyn., 25(1), 96–104.
Yavuzoglu, E., et al. (2011). “Verification of control moment gyroscopes based attitude control systems for agile satellite missions.” Proc., 5th Int. Conf. on Recent Advances in Space Technologies, IEEE, New York, 547–553.
Yoon, H., and Tsiotras, P. (2004). “Singularity analysis of variable-speed control moment gyros.” J. Guidance Control Dyn., 27(3), 374–386.
Information & Authors
Information
Published In
Journal of Aerospace Engineering
Volume 30 • Issue 5 • September 2017
Copyright
©2017 American Society of Civil Engineers.
History
Received: Sep 30, 2016
Accepted: Feb 22, 2017
Published online: May 18, 2017
Published in print: Sep 1, 2017
Discussion open until: Oct 18, 2017
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.