Clogging of Pervious Monolayers Subjected to Radial Flow
Publication: International Journal of Geomechanics
Volume 7, Issue 1
Abstract
Particle migration within porous networks often results in permeability reductions due to clogging. In many field applications, fluids and entrained particles travel radially toward producing wells. The nonhomogeneous velocity field associated with radial flow produces particle-level force variations that in turn lead to spatially dependent pore-scale mechanisms and unique clogging phenomena. The fluid-driven migration and entrapment of particles in radial flow is studied experimentally in custom-built pervious monolayers that allow for direct visualization of clogging processes. Experimental results demonstrate that in particular hydrodynamic conditions, particle clogging evolves in the form of a self-stabilizing clogging ring that localizes at a characteristic radial distance that depends on the initial producing flow rate. Gradual clogging by surface deposition of particles is observed in less severe hydrodynamic conditions. The particle migration and clogging processes observed are analyzed by considering particle-level force balance through dimensionless parameters.
Get full access to this article
View all available purchase options and get full access to this article.
Acknowledgments
This research project was sponsored by the San Diego State University Research Foundation, whose support is greatly acknowledged. The opinions, interpretations, and conclusions presented here are those of the writers, and not necessarily of the San Diego State University Research Foundation. The writers acknowledge the helpful suggestions and comments offered by Kenneth Walsh and Edward Beighley.
References
Bertram, G. E. (1940). “Experimental investigation of protective filters.” Soil mechanics series Vol. 7, Harvard University Press, Cambridge, Mass.
Bonala, M. V. S., and Reddi, L. N. (1998). “Physicochemical and biological mechanisms of soil clogging: An overview. “Filtration and drainage in geotechnical and geoenvironmental engineering.” Geotech. Spec. Publ., 78(1), 43–68.
Bouhroum, A., and Civan, F. (1994). “Study of particulates migration in gravel pack.” Proc., Int. Symp. on Formation Damage Control, Society of Petroleum Engineers, Lafayette, La., 75–92.
Bratli, R. K., and Risnes, R. (1981). “Stability and failure of sand arches.” J. Soc. Pet. Eng., 21(2), 236–248.
Cerda, C. M. (1987). “Mobilization of kaolinite fines in porous media.” Colloids Surf., 29(1–3), 219–241.
Gruesbeck, C., and Collins, R. E. (1982). “Entrainment and deposition of fine particles in porous media.” J. Soc. Pet. Eng., 22(6), 847–856.
Ives, K. J., and Horner, R. M. W. (1973). “Radial filtration.” Proc., Inst. of Civil Engineers Part 1, Design and Construction, Institution of Civil Engineers, London, Vol. 55, 229–249.
Khilar, K. C., and Fogler, H. S. (1998). Migration of fines in porous media, Kluwer Academic, Dordrecht, The Netherlands.
Kia, S. F., Fogler, H. S., and Reed, M. G. (1987). “Effect of pH on colloidally induced fines migration.” J. Colloid Interface Sci., 118(1), 158–168.
Krueger, R. F., Vogel, L. C., and Fischer, P. W. (1967). “Effect of pressure drawdown on clean-up of clay- or slit-blocked sandstone.” J. Pet. Technol., 19(1), 397–403.
Liu, X., and Civan, F. (1994). “Formation damage and skin factors due to filter cake formation and fines migration in the near-wellbore region.” Proc., Int. Symp. on Formation Damage Control, Society of Petroleum Engineers, Lafayette, La., 259–274.
McDowell-Boyer, L. M., Hunt, J. R., and Sitar, N. (1986). “Particle transport through porous media.” Water Res., 22(13), 1901–1921.
Muecke, T. W. (1979). “Formation fines and factors controlling their movement in porous media.” JPT, J. Pet. Technol., 31(1), 144–150.
Powers, J. P. (1992). Construction dewatering: New methods and applications, 2nd ed., Wiley, New York.
Ramachandran, V., and Fogler, H. S. (1999). “Plugging by hydrodynamic bridging during flow of stable colloidal particles within cylindrical pores.” J. Fluid Mech., 385(1), 129–156.
Scheidegger, A. E. (1957). The physics of flow through porous media, MacMillan, New York.
Sharma, M. M., Chamoun, H., Sharma, D. S. H. S. R., and Schechter, R. S. (1992). “Factors controlling the hydrodynamic detachment of particles from surfaces.” J. Colloid Interface Sci., 149(1), 121–134.
Sherard, J. L., Dunnigan, L. P., and Talbot, J. R. (1984). “Basic properties of sand and gravel filters.” J. Geotech. Engrg., 110(6), 684–700.
Vaidya, R. N., and Fogler, H. S. (1990). “Formation damage due to colloidally induced fines migration.” Colloids Surf., 50(12), 215–229.
Valdes, J. R. (2002). “Fines migration and formation damage-microscale studies.” Ph.D. dissertation, Georgia Institute of Technology, Atlanta.
Valdes, J. R., and Santamarina, J. C. (2006). “Particle clogging in radial flow: Microscale mechanisms.” Soc. Pet. Eng. J., 11(2), 193–198.
Vigneswaran, S., Thiyagaram, M., and Ben Aim, R. (1985). “Mathematical modeling of radial flow filtration and its application to groundwater recharge problems.” AIChE J., 31(11), 1929–1933.
Information & Authors
Information
Published In
Copyright
© 2007 ASCE.
History
Received: May 17, 2005
Accepted: Mar 15, 2006
Published online: Jan 1, 2007
Published in print: Jan 2007
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.