Optimum Soil Grading for the Soil-Cement Blocks
Publication: Journal of Materials in Civil Engineering
Volume 19, Issue 2
Abstract
Large numbers of soil-cement block masonry buildings exist in India and many other countries. The paper deals with an experimental study on the influence of soil grading on the characteristics of soil-cement blocks and shear-bond strength of soil-cement block masonry triplets. Influence of clay content of the soil-cement block on strength, absorption and durability characteristics, and interfacial mortar-block bond strength has been examined. Some of the major conclusions of the study are: (1) optimum clay content leading to maximum strength is in the range of 14–16%; (2) saturated water content of the blocks increases with increase in clay content of the block; (3) initial rate of absorption decreases with increase in clay content of the block; (4) weight loss after ASTM wire scratch test is minimum when the clay content of the block is about 16%; and (5) optimum clay content for the highest modulus for the blocks and for highest shear-bond strength is about 16%.
Get full access to this article
View all available purchase options and get full access to this article.
References
ASTM. (1989). “Standard test methods for wetting and drying of compacted soil-cement mixtures.” D 559, West Conshohocken, Pa.
ASTM. (1994). “Standard test methods of sampling and testing brick and structural clay tile.” C 67-94, West Conshohocken, Pa.
Bokhari, A. H. (1976). “A study of soil-cement blocks in building construction.” MSc (Engineering) thesis, Dept. of Civil Engineering, Univ. of Engineering and Technology, Lahore, Pakistan.
Bureau of Indian Standards. (1989). “Specification for 43 grade ordinary Portland cement.” 8112-1989, New Delhi, India.
Bureau of Indian Standards. (1992). “Methods of tests of burnt clay building bricks.” 3495-1992, New Delhi, India.
Dietz, A. G. H. (1979). Low-cost housing technology—An east west perspective, L. J. Goodman, R. P. Pama, E. G. Tabujara, R. Razani, and F. J. Buria, eds., East-West Center, Hawaii.
Fitzmaurice, R. F. (1958). Manual on stabilised soil construction for housing, U.N. Technical Assistance Program, New York.
Gumaste, K. S., Venkatarama Reddy, B. V., Nanjunda Rao, K. S., and Jagadish, K. S. (2004). “Properties of burnt bricks and mortars in India.” Masonry Int., 17(2), 45–52.
Heathcote, K. A. (1995). “Durability of earth wall buildings.” Construction and building materials, Vol. 9, No. 3, Elsevier Science, Amsterdam, The Netherlands, 185–189.
Houben, H., and Guillaud, H. (1994). Earth construction–A comprehensive guide, Intermediate Technology Publications, London.
Lunt, M. G. (1980). “Stabilised soil blocks for buildings.” Overseas Building Notes No. 184.
Madhavan, R., and Narsinga Rao, C. N. (1949). Rep. on Labour Housing Scheme, The City Improvement Trust Board, Bangalore, India.
Middleton, G. F. (revised by Schneider, L. M.). (1987). Earth-wall construction, bulletin 5, 4th Ed., Commonwealth Scientific and Industrial Research Organization, Sydney, Australia.
Mitra, J. N. (1951). “Suitability of soil for stabilised soil houses for Rangawan dam colony.” Indian Concr. J., 15, 234–238.
Mukerji, K. (1994). Stabilisers and mortars for compressed earth blocks, GATE-ISAT, Eschborn, Germany.
Olivier, M., and Mesbah, A. (1987). “Influence of different parameters on the resistance of earth, used as a building materials.” Int. Conf. on Mud Architecture, Trivandrum, India.
Portland Cement Association. (1956). Soil-cement laboratory handbook, Skokie, Ill.
Sarangapani, G., Venkatarama Reddy, B. V., Caspar, J. W., and Groot, P. (2002). “Water loss from fresh mortars and bond strength development in low strength masonry.” Masonry Int., 15(2), 42–47.
Spence, R. J. S. (1975). “Predicting the performance of soil-cement as a building material in tropical countries.” Building science, 10.
Venkatarama Reddy, B. V. (2002). “Long-term strength and durability of stabilised mud blocks.” Proc., 3rd Int. Conf. on Non-Conventional Materials and Technologies, Construction Publishing House, Hanoi, Vietnam, 422–431.
Venkatarama Reddy, B. V., and Gupta, A. (2005). “Characteristics of cement-soil mortars.” Mater. Struct., 38(280), 639–650.
Venkatarama Reddy, B. V., and Gupta, A. (2006). “Tensile bond strength of soil-cement block masonry couplets using cement-soil mortars.” J. Mater. Civ. Eng., 18(1), 36–45.
Venkatarama Reddy, B. V., and Jagadish, K. S. (1993). “The static compaction of soils.” Geotechnique, 43(2), 337–341.
Venkatarama Reddy, B. V., and Jagadish, K. S. (1995). “Influence of soil composition on the strength and durability of soil-cement blocks.” Indian Concr. J., 69(9), 517–524.
Venkatarama Reddy, B. V., and Walker, P. (2005). “Stabilised mud blocks: Problems, prospects.” Proc., Int. Earth Building Conf. EarthBuild 2005, Sydney, Australia, 63–75.
Venkatarama Reddy, B. V., Williams, T., and Walker, P. (2003). “Durability of stabilised mud block buildings in Southern India.” Proc., 9th Int. Conf. on the Study and Conservation of Earthen Architecture Terra 2003, Yazd, Iran, 492–503.
Verma, P. L., and Mehra, S. R. (1950). “Use of soil-cement in house construction in the Punjab.” Indian Concr. J., 24, 91–96.
Walker, P. (1999). “Bond characteristics of earth block masonry.” J. Mater. Civ. Eng., 11(3), 249–256.
Walker, P. (2004). “Strength and erosion characteristics of earth blocks and earth block masonry.” J. Mater. Civ. Eng., 16(5), 497–506.
Walker, P., and Stace, T. (1997). “Properties of some cement stabilized compressed earth blocks and mortars.” Mater. Struct., 30, 545–551.
Wolfskill, L. S., Dunlop, W. A., and Callaway, B. M. (1970). Handbook for building homes of earth, Dept. of Housing and Urban Development, Office of International Affairs, Washington, D.C.
Yttrup, P. J., Diviny, K., and Sottile, F. (1981). “Development of a drip test for the erodibility of mud bricks.” Deakin Univ., Geelong, Australia.
Information & Authors
Information
Published In
Copyright
© 2007 ASCE.
History
Received: Apr 28, 2005
Accepted: Oct 31, 2005
Published online: Feb 1, 2007
Published in print: Feb 2007
Notes
Note. Associate Editor: Manoochehr Zoghi
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.