Effectiveness of Covers and Liners Made of Red Mud Bauxite and/or Cement Kiln Dust for Limiting Acid Mine Drainage
Publication: Journal of Environmental Engineering
Volume 131, Issue 8
Abstract
This paper presents a laboratory investigation to evaluate the capacity of alkaline residues to inhibit acid mine drainage. Column tests were used to evaluate the geochemical behavior of cement kiln dust (CKD) and red mud bauxite (RMB) used as covers, liners, or mixed with acid producing tailings and waste rocks. The most important indicators of neutralization are pH and the concentrations of metals in solution. Initial leachate pH of samples with an alkaline cover composed of 10% CKD or 10% of a mixture of CKD and RMB was low, but rapidly increased to near 7.0 and stabilized for the duration of this study. The use of alkaline materials as a liner had a positive effect on the reduction of Fe, and other metals such as Cu and Zn concentrations and the number of viable bacteria. In the cases where the alkaline layer was used as a liner or mixed with the waste rocks, near neutral pH values were rapidly reached in the leachate. However, in these columns the leachate pH values decreased over time.
Get full access to this article
View all available purchase options and get full access to this article.
Acknowledgment
This study has been supported by the National Science and Engineering Research Council of Canada (NSERC).
References
Aubertin, M., et al. (1995). “Évaluation en laboratoire de barrières sèches construites à partir de résidus miniers.” Projet CDT 1622, Report MEND/NEDEM 2.22.2a, École Polytechnique (in French).
Doye, I., and Duchesne, J. (2003). “Neutralisation of acid mine drainage with alkaline industrial residues: Laboratory investigation using batch-leaching tests.” Appl. Geochem., 18, 1197–1213.
Duchesne, J., and Reardon, E. J. (1998). “Determining controls on element concentrations in cement kiln dust leachate.” Waste Manage., 18, 339–350.
Lafleur, R., Desjardins-Roy, E., Couillard, D., and Guay, R. (1993). Biohydrometallurgy technologies, II. Fossil energy materials bioremediation, microbial physiology, M. L. Apel and C. L. Brierley eds., Torma, Vol. 2, 433.
Lamontagne, A., Fortin, S., Poulin, R., Tassé, N., and Lefebvre, R. (2000). “Layered co-mingling for the contruction of waste rock piles as a method to mitigate acid mine drainage—Laboratory investigations.” Proc. Fifth Int. Conf. on Acid Rock Drainage, ICARD 2000, Denver, Colo., Vol. 2, 779–788.
Lamontagne, A., Isabel, D., Paradis, M., Vézina, S., and Clément, B. (2002). Utilisation des boues rouges pour la restauration de rejets miniers générateurs de drainage minier acide—Cas du site de Dunraine, NEDEM, Abitibi, Canada (in French).
Lapakko, K. A., Antonson, D. A., and Wagner, J. R. (2000). “Mixing of rotary kiln fines with fine-grained acid-producing.” Proc. Fifth Int. Conf. on Acid Rock Drainage, ICARD 2000, Denver, Vol. 2, 901–910.
Nicholson, R. V., Gillham, R. W., Cherry, J. A., and Reardon, E. J. (1989). “Reduction of acid generation in mine tailings through the use of moisture-retaining cover layers as oxygen barriers.” Can. Geotech. J., 26, 1.
Perry, E. F., and Bradly, K. B. (1995). “Influence of neutralization potential on surface mine drainage quality in Pennsylvania.” Proc., Sixteenth Annual Surface Mine Drainage Task Force Symposium, West Virginia Publication Services, Morgantown, W.Va.
Poulin, R., Hadjigeorgiou, J., and Lawrence, R. W. (1996). “Layered mine waste co-mingling for mitigation of acid rock drainage.” Trans. Inst. Min. Metall., Sect. A, 105, 55–62.
Rasmusson, A., and Erickson, J. C. (1986). “Capillary barriers in covers for mine tailings dumps.” Rep. 3307, The National Swedish Environmental Protection Board.
Rich, D. H., and Hutchison, K. R. (1990). “Neutralization and stabilization of combined refuse using lime kiln dust at High Power Mountain.” Vol. 1, J. Skousen, J. Sencindiva, and D. Samuel, eds., Proc., Mining and Reclamation Conf. and Exhibition, Charleston, W.Va, 55–59.
Rose, S., and Elliott, W. C. (2000). “The effect of pH regulation upon the release of sulfate from ferric precipitates formed in acid mine drainage.” Appl. Geochem., 15, 27–34.
Rose, A. W., Phelps, L. B., Parizek, R. R., and Evans, D. R. (1995). “Effectiveness of lime kiln flue dust in preventing acid mine drainage at the Kauffman surface coal mine, Clearfield County, Pennsylvania.” National Meeting of the American Society for Surface Mining and Reclamation, Gillette, Wyo., 159–171.
Skousen, J., et al. (1998). Handbook of technologies for avoidance and remediation of acid mine drainage, The National Mine Land Reclamation Center, Morgantown, W.Va.
Smith, M. W., and Brady, K. B. (1998). Coal mine drainage prediction and pollution prevention in Pennsylvania, Report of the Pennsylvania Department of Environmental Protection, Brady, Smith, and Schveck, eds.
Wilson, G. W., Newman, L. L., and Ferguson, K. D. (2000). “The co-disposal of waste rock and tailings.” Proc. Fifth Int. Conf. On Acid Rock Drainage (ICARD), Denver, 789–796.
Wiram, V. P., and Naumann, H. E. (1995). “Alkaline additions to the backfill: A key mining/reclamation component to acid mine drainage prevention.” Sixteenth Annual Surface Mine Drainage Task Force Symposium, West Virginia Publication Services, Morgantown, W.Va.
Information & Authors
Information
Published In
Copyright
© 2005 ASCE.
History
Received: Oct 7, 2003
Accepted: Nov 15, 2004
Published online: Aug 1, 2005
Published in print: Aug 2005
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.