Study of Sewage Sludge Pyrolysis Mechanism and Mathematical Modeling
Publication: Journal of Environmental Engineering
Volume 127, Issue 7
Abstract
The pyrolysis of sewage sludge, with and without ZnCl2 activation, was monitored using TGA-FTIR, with the results utilized in a proposed decomposition mechanism. For the pyrolysis of sludge without ZnCl2 activation, three global stages of mass loss occurred and are proposed as dehydration, initial depolymerization, and deep degradation. For the pyrolysis of sludge with ZnCl2 activation, apart from these three stages, an additional mass loss stage could be also observed at high temperature. It is suggested this results from the evaporation of ZnCl2. To make a comparison between these two cases, it was found that the pyrolysis of sludge with ZnCl2 activation had a longer dehydration phase and a shorter degradation phase. Based on the speculated mechanism, a kinetic model of four consecutive competitive reactions was adopted to simulate the pyrolysis of sewage sludge with and without ZnCl2 activation. Globally, the proposed model was able to fit the experimental data very well for both cases, with the correlation coefficients above 0.99.
Get full access to this article
View all available purchase options and get full access to this article.
References
1.
Ahuja, P., Singh, P. C., Upadhyay, S. N., and Kumar, S. ( 1996). “Kinetics of biomass and sewage sludge pyrolysis: Thermogravimetric and sealed reactor studies.” Int. J. Chem. Technol., 3, 306–312.
2.
Alberty, R. A., and Silbey, R. J. ( 1992). Physical chemistry, Wiley, New York.
3.
Bansal, R. C., Donnet, J. B., and Stoeckli, F. ( 1988). “Chapter 1, Manufacture of active carbons.” Active Carbon, Marcel Dekker, New York, 1–26.
4.
Beeckmans, J. M., and Park, C. Ng. ( 1971). “Pyrolyzed sewage sludge: Its production and possible utility.” Envir. Sci. and Technol., 5(1), 69–71.
5.
Bhandare, P. S., and Krishnan, K. ( 1997). “Applications of TGA-FT-IR analysis to polymer systems.” Mikrochim Acta, 14, 729–731.
6.
Bhandare, P. S., Lee, B. K., and Krishnan, K. ( 1997). “Study of pyrolysis and incineration of disposable plastics using combined TG/FT-IR technique.” J. Therm. Anal., 49, 361–366.
7.
Bilitewski, B. ( 1979). “Production and possible applications of activated carbon from waste.” Proc., Recycling Berlin '79, Int. Recycling Congr., 714–721.
8.
Chiang, P. C., and You, J. H. ( 1987). “Use of sewage sludge for manufacturing adsorbents.” Can. J. Chem. Engrg., 65, 922–927.
9.
Conesa, J. A., Marcilla, A., Moral, R., Moreno-Caselles, J., and Perez-Espinosa, A. ( 1998). “Evolution of gases in the primary pyrolysis of different sewage sludges.” Thermochim. Acta, 313(1), 63–73.
10.
Conesa, J. A., Marcilla, A., Prats, D., and Rodriguez-Pastor, M. ( 1997). “Kinetic study of the pyrolysis of sewage sludge.” Waste Mgmt. and Res., London, 15(3), 293–305.
11.
Dumplemann, R., Richarz, W., and Stammbach, M. R. ( 1991). “Kinetic studies of the pyrolysis of sewage sludge by TGA and comparison with fluidized beds.” Can. J. Chem. Engrg., 69, 953–963.
12.
Fatunla, S. O. ( 1988). “The backward differentiation formula.” Numerical methods for initial value problems in ordinary differential equations, Academic, Boston, 211–215.
13.
Galbacs, G., Kantor, T., Moens, L., and Dams, R. ( 1998). “Mass spectrometric studies of thermal decomposition products of reference materials for use in solid sampling atomic spectrometry.” Spectrochim. Acta, 53(9), 1335–1346.
14.
Groenewoud, W. M., and Jong, W. ( 1996). “The thermogravimetric analyser-coupled-Fourier transform infrared/mass spectrometry technique.” Thermochim. Acta, 286, 341–354.
15.
Jeyaseelan, S., and Lu, G. Q. ( 1996). “Development of adsorbent/catalyst from municipal wastewater sludge.” Water Sci. and Technol., 34, 499–505.
16.
Martin, M. J., Balaguer, M. D., and Rigola, M. ( 1996). “Feasibility of activated carbon production from biological sludge by chemical activation with ZnCl2 and H2SO4.” Envir. Technol., London, 17, 667–672.
17.
Materazzi, S. ( 1997). “Thermogravimetry-Infrared spectroscopy (TG-FTIR) coupled analysis.” Appl. Spec. Rev., 32(4), 385–404.
18.
Rao, S. S. ( 1984). “The complex method.” Optimization theory and applications, Wiley Eastern, New Delhi, 345–348.
19.
Schwefel, H. P. ( 1981). “Complex strategy of box.” Numerical optimization of computer models, Wiley, New York, 59–65.
20.
Tay, J. H., Graham, N., Chen, X. G., and Jeyaseelan, S. ( 1999). “Optimizing preparation of activated carbon from digested sewage sludge and peanut shells: Influence of preparation conditions.” Proc., 7th IAWQ Asia-Pacific Regional Conf., 1005–1010.
21.
Urban, D. L., and Antal Jr., M. J. ( 1982). “Study of the kinetics of sewage sludge pyrolysis using DSC and TGA.” Fuel, 61, 799–806.
22.
Wang, H., Zhou, H. S., Sun, X. X., and Zhou, H. ( 1999). “Comparisons of sewage sludge and coal pyrolysis using TGA-FTIR.” Huazhong Ligong Daxue Xuebao, 27(9), 38–40.
Information & Authors
Information
Published In
Journal of Environmental Engineering
Volume 127 • Issue 7 • July 2001
Pages: 585 - 593
History
Received: Dec 29, 1999
Published online: Jul 1, 2001
Published in print: Jul 2001
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.