VFA Production in Thermophilic Aerobic Digestion of Municipal Sludges
This article has a reply.
VIEW THE REPLYPublication: Journal of Environmental Engineering
Volume 126, Issue 5
Abstract
Volatile fatty acids (VFA) are a principal carbon substrate used in biological nutrient removal processes, and an increase in their concentration can enhance process performance. In the autothermal thermophilic aerobic digestion (ATAD) of primary sludge, a reduction in both aeration and retention time had been reported to enhance VFA production. However, smaller wastewater treatment plants, which are suitable for ATAD, often combine sludge in a single digestion process for convenience. Consequently, research was undertaken to determine if a mixture of primary and secondary sludge would increase VFA production, compared to primary sludge alone, in the first stage of ATAD. Secondary sludge was predicted to further enhance VFA production by providing the required substrate “prepackaged” in the correct ratios. The results illustrated that the incorporation of secondary sludge into the primary sludge feed resulted in increased production and accumulation of VFA. The greatest production and accumulation were produced with the digestion of 100% secondary sludge. In addition, analysis of nutrient species confirmed that the mixing of primary and secondary sludge, as well as the ATAD of mixed and secondary sludge, results in the release of stored phosphorus and an increase in ammonia nitrogen.
Get full access to this article
View all available purchase options and get full access to this article.
References
1.
Anderson, B. C., and Mavinic, D. S. (1993). “Behaviour and control of nutrients in the enhanced aerobic digestion process: Pilot-scale studies.” Envir. Technol., 14(4), 301–318.
2.
Anderson, B. C., Mavinic, D. S., and Oleszkiewicz, J. A. (1995). “Stabilization of combined wastewater sludge: Anaerobic processes.” Can. J. Civ. Engrg., 22(2), 223–224.
3.
Atherton, H. ( 1995). “Primary sludge fermentation using a pilot-scale mainstream fermenter to enhance biological phosphorus removal,” MASc thesis, Dept. of Civ. Engrg., University of British Columbia, Vancouver, Canada.
4.
Baier, H., and Zwiefelhofer, H. P. ( 1991). “Effects of aerobic thermophilic pretreatment on anaerobic sludge stabilisation and subsequent treatment steps.” Treatment and Use of Sewage Sludge and Liquid Agricultural Wastes, P. L'Hermite, ed., Elsevier, New York, 520–534.
5.
Boulanger, M. ( 1995). “The effect of varying air supply upon supernatant quality in autoheated thermophilic aerobic digesters treating waste sludge from a biological phosphorus removal process,” MASc thesis, Dept. of Civ. Engrg., University of British Columbia, Vancouver, Canada.
6.
Boulanger, M., Fries, K., and Mavinic, D. C. (1995). “The effect of air supply on quality of return flows from ATAD sludge stabilization.” Proc., WEF 68th Annu. Conf. and Exposition, Water Environment Federation, Miami Beach, Fla., 303–311.
7.
Boulanger, M., Mavinic, D. S., and Nemeth, L. (1994). “The effect of air supply on solids destruction and nutrient balance for thermophilic aerobic digesters.” Proc., CSCE Evir. Engrg. Conf., Canadian Society of Civil Engineering, Winnipeg, Canada, Vol. III, 67–76.
8.
Burnett, C. H. (1995). “An overview of autothermal thermophilic aerobic digestion facilities in Europe and Canada.” Proc., WEF Specialty Conf.—New and emerging Envir. Technols. and Products for Wastewater Treatment and Stormwater Collection, Water Environment Federation, Miami, Fla., 5-33–5-44.
9.
Chu, A. ( 1995). “Volatile fatty acid metabolism in thermophilic aerobic digestion of sludge,” PhD thesis, Dept. of Civ. Engrg., University of British Columbia, Vancouver, Canada.
10.
Chu, A., Mavinic, D. S., Kelly, H. G., and Ramey, W. D. (1994). “Volatile fatty acid production in thermophilic aerobic digestion of sludge.” Water Res., Oxford, England, 28(7), 1513–1522.
11.
Deeney, K., Hahn, H., Leonhard, D., and Heidman, J. (1991). “Autoheated thermophilic aerobic digestion.” Water Envir. and Technol., October, 65–72.
12.
Fothergill, S. ( 1996). “The effect of primary and secondary sludge mix ratios on VFA production in thermophilic aerobic digestion using pilot scale ATAD units,” MASc thesis, Dept. of Civ. Engrg., University of British Columbia, Vancouver, Canada.
13.
Gould, M. S., and Drnevich, R. F. (1978). “Autothermal thermophilic aerobic digestion.”J. Envir. Engrg. Div., ASCE, 104(2), 259–270.
14.
Hamer, G. ( 1987). “Fundamental aspects of aerobic thermophilic biodegradation.” Treatment of sewage sludge: Thermophilic aerobic digestion and processing requirements for land filling, A. M. Bruce, F. Colin, and P. J. Newman, eds., Elsevier, London, 2–19.
15.
Hamer, G., and Zwiefelhofer, H. P. (1986). “Aerobic thermophilic hygienization—A supplement to anaerobic mesophilic waste sludge digestion.” Chem. Engrg. Res. and Des., 6(6), 417–424.
16.
Kelly, H. G. (1990). “Demonstration of an improved digestion process for municipal sewage sludges,” Contract KE405-8-6575/01-SE, UP-D8-010, Supply and Services Canada.
17.
Kelly, H. G. (1991). “Autothermal thermophilic aerobic digestion: A two-year appraisal of Canadian facilities.” Proc., Envir. Engrg. Spec. Conf., ASCE, New York, 296–301.
18.
Kelly, H. G., Jennings, C., Sivyer, D., Robinson, L., Frese, H., and Cale, C. (1995). “Hot tips for autothermal aerobic digestion.” Operations Forum, 12(5).
19.
Kelly, H. G., Melcer, H., and Mavinic, D. S. (1993). “Autothermal thermophilic aerobic digestion of municipal sludges: A one-year, full-scale demonstration project.” Water Envir. Res., 65(7), 849–861.
20.
Knezevic, Z., Mavinic, D. S., and Anderson, B. C. (1995). “Pilot scale evaluation of anaerobic co-digestion of primary and pretreated waste activated sludge.” Water Envir. Res., 67(5), 835–841.
21.
Mason, C. A., Hamer, G., Fleischmann, T., and Lang, C. (1987a). “Aerobic thermophilic biodegradation of microbial cells.” Appl. Microbiol. Biotechnol., 25, 568–576.
22.
Mason, C. A., Hamer, G., Fleischmann, T., and Lang, C. (1987b). “Bioparticulate Solubilization and Biodegradation in Semi-Continuous Aerobic Thermophilic Digestion.” Water Air Soil Pollution, Dordrecht, The Netherlands, 34(August), 399–407.
23.
Mavinic, D. S., Niedbala, D., Hall, E. R., and Koch, F. A. (1996). “Pilot-scale studies of anaerobic co-digestion of combined sludges from a full-scale BNR wastewater treatment plant.” Proc., WEF 69th Annu. Conf. and Exposition, Water Environment Federation, Miami, Fla., 151–160.
24.
McIntosh, K. B., and Oleszkiewicz, J. A. (1996). “Volatile fatty acid production in aerobic thermophilic pre-treatment of sludge.” Proc., 4th Envir. Engrg. Spec. Conf., Canadian Society for Civil Engineering, May 29–June 1, 1996, Edmonton, AB, Canada, 373–382.
25.
Niedbala, D. ( 1995). “Pilot-scale studies of the anaerobic digestion of combined wastewater sludges and mitigation of phosphorus release,” MASc thesis, Dept. of Civ. Engrg., University of British Columbia, Vancouver, Canada.
26.
Ponti, C., Sonnleitner, B., and Fiechter, A. (1995). “Aerobic thermophilic treatment of sewage sludge at pilot plant scale—1. Operating conditions and 2. Technical solutions and process design.” J. Biotechnol., 38, 173–19.
27.
Rabinowitz, B., and Barnard, J. L. ( 1995). “Sludge handling for biological nutrient removal plants.” IAWQ 1994–95 Yearbook, International Association of Water Quality, London, 11–19.
28.
Standard methods for examination of water and wastewater. (1989). 18th Ed., American Public Health Association, American Water Works Association, and Water Pollution Control Federation, Washington, D.C.
29.
U.S. Environmental Protection Agency (EPA). (1990). “Autothermal thermophilic aerobic digestion of municipal wastewater sludge.” Environmental regulations and technology, Cincinnati, Ohio. EPA/625/10-90/007, September.
Information & Authors
Information
Published In
Journal of Environmental Engineering
Volume 126 • Issue 5 • May 2000
Pages: 389 - 396
History
Received: Feb 8, 1999
Published online: May 1, 2000
Published in print: May 2000
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.