Effects of Moisture on Warming of Activated Carbon Bed during VOC Adsorption
Publication: Journal of Environmental Engineering
Volume 125, Issue 12
Abstract
Thermal waves resulting from the dynamic adsorption of organic vapor present in air on a granular activated carbon (GAC) filter were studied. An experimental design was carried out to determine the influential factors among the relative humidity of air (0–60%), the initial water content of the activated carbon (0–9.8%), and the volatile organic compound (VOC) concentration (0–50 g⋅m−3, i.e., 0–20,700 ppmv for acetone). The temperature increase is a function of the initial VOC concentration as well as the energy flux released. The warming of the adsorber is shown to be important for the adsorption of high VOC concentrations on a dry carbon bed, but the thermal amplitude is distinctly reduced when the GAC is initially wet because of water desorption. The moisture content of the air in the range of 0–95% is not found to be a prominent factor affecting both the adsorption capacity and the warming of the GAC bed for the high VOC concentration tested (20,700 ppmv of acetone). Temperature monitoring provides interesting information about the adsorption process, and the mechanisms involved are discussed.
Get full access to this article
View all available purchase options and get full access to this article.
References
1.
Baudu, M., Le Cloirec, P., and Martin, G. (1993). “First approach of desorption energies of water and organic molecules onto activated carbon by differential scanning calorimetry studies.” Water Res., 27(1), 69–76.
2.
Biron, E., and Evans, M. J. B. (1998). “Dynamic adsorption of water-soluble and insoluble vapours on activated carbon.” Carbon, 36(7–8), 1191–1197.
3.
Busmundrud, O. (1993). “Vapour breakthrough in activated carbon beds.” Carbon, 31(2), 279–286.
4.
Carrasco-Martin, F., Mueden, A., Centeno, T. A., Stoeckli, F., and Moreno-Castilla, C. (1997). “Water adsorption on activated carbons with different degrees of oxidation.” J. Chem. Soc. Faraday Trans., U.K., 93(12), 2211–2215.
5.
Chou, M. S., and Chiou, J. H. (1997). “Modeling effects of moisture on adsorption capacity of activated carbon for VOCs.”J. Envir. Engrg., ASCE, 123(5), 437–443.
6.
Critoph, R. E., and Turner, L. (1995). “Heat transfer in granular activated carbon beds in the presence of adsorbable gases.” Int. J. Heat Mass Transfer, 38(9), 1577–1585.
7.
Gong, R., and Keener, T. C. (1993). “A qualitative analysis of the effects of water vapor on multicomponent vapor-phase carbon adsorption.” J. Air Waste Mgmt. Assn., 43(6), 864–872.
8.
Graham, J. R., and Ramaratnam, M. (1993). “Recover VOCs using activated carbon.” Chemical Engrg., (Feb.), 6–12.
9.
Groszek, A. J. (1998). “Flow adsorption microcalorimetry.” Thermochimica acta, 312(1–2), 133–143.
10.
Hall, C. R., Holmes, R. J., and Lawston, I. W. (1991). “Further observations on the displacement of pre-adsorbed water from BPL activated carbon by chloropicrin vapour.” Adsorp. Sci. Technol., 8(2), 69–74.
11.
Harrell, W. A., Sewall, J. O., and Walsh, T. J. (1979). “Control of malodorous compounds by carbon adsorption.” Loss Prevention, 12, 124–127.
12.
Henning, K. D., Bongartz, W., and Degel, J. ( 1989). “Adsorption recovery of problematic solvents.” CarboTech Co., Essen, Germany.
13.
Henning, K. D., and Degel, J. ( 1990). “Activated carbon for solvent recovery.” CarboTech Co., Essen, Germany.
14.
Huang, C. C., and Fair, J. R. (1988). “Study of the adsorption and desorption of multiple adsorbates in a fixed bed.” AIChE J., 34(11), 1861–1877.
15.
Jacob, P., and Tondeur, D. (1983). “Non-isothermal gas adsorption in fixed beds—II. Non-linear equilibrium theory and `guillotine' effect.” Chemical. Engrg. J, 26, 41–50.
16.
Jonas, L. A., Sansone, E. B., and Farris, T S. (1985). “The effect of moisture on the adsorption of chloroform by activated carbon.” Am. Industrial Hygiene Assn. J, 46(1), 20–29.
17.
Kaguei, S., Yu, Q., and Wakao, N. (1985). “Thermal waves in an adsorption column.” Chemical Engrg. Sci., 40(7), 1069–1076.
18.
Le Cloirec, P. ( 1998). Les composés organiques volatils dans l'environnement. Lavoisier, Tec & Doc, Paris
19.
Le Cloirec, P., and Martin, G. (1988). “1H NMR investigation on phenol saturated and unsaturated activated carbon: Quantification and exchange behavior of protons.” Carbon, 26(3), 275–282.
20.
Meunier, F., Sun, L. M., Kraehenbuehl, F., and Stoeckli, F. (1988). “A comparison of experimental and theoretical adsorption kinetics of dichloromethane vapour by active carbon under nonisothermal conditions.” J. Chem. Soc. Faraday Trans., U.K., 84(6), 1973–1983.
21.
Müller, E. A., Rull, L. F., Vega, L. F., and Gubbins, K. E. (1996). “Adsorption of water on activated carbon: A molecular simulation study.” J. Physical Chemistry, 100(4), 1189–1196.
22.
Okazaki, M., Tamon, H., and Toei, R. (1978). “Prediction of binary adsorption equilibria of solvent and water vapor on activated carbon.” J. Chem. Engrg. Japan, 11(3), 209–215.
23.
Pan, C. Y., and Basmadjian, D. (1970). “An analysis of adiabatic sorption of single solutes in fixed beds: Pure thermal wave formation and its practical implications.” Chemical Engrg. Sci., 25, 1653–1664.
24.
Rudling, J. ( 1990). “Heats of adsorption of various organics solvents on activated carbon.” Application Note 451, LKB Bromma, Sweden.
25.
Ruthven, D. M. (1984). Principles of adsorption and adsorption processes. Wiley, New York.
26.
Ruthven, D. M., Garg, D. R., and Crawford, R. M. (1975). “The performance of molecular sieve adsorption columns: Non-isothermal systems.” Chemical Engrg. Sci., 30, 803–810.
27.
Sado, G., and Sado, M. C. ( 1991). “Les plans d'expériences: De l'expérimentation à l'assurance qualité.” Association française de normalisation, Technique, Paris.
28.
Stoeckli, F., Jakubov, T., and Lavanchy, A. (1994). “Water adsorption in active carbons described by the Dubinin-Astakov equation.” J. Chem. Soc. Faraday Trans., U.K., 90(5), 783–786.
29.
Werner, M. D. (1985). “The effects of relative humidity on the vapor phase adsorption of trichloroethylene by activated carbon.” Am. Industrial Hygiene Assn. J., 46(10), 585–590.
30.
Yoshida, H., and Ruthven, D. M. (1983). “Dynamic behavior of an adiabatic adsorption column—I.” Chemical Engrg. Sci., 38(6), 877–884.
Information & Authors
Information
Published In
Journal of Environmental Engineering
Volume 125 • Issue 12 • December 1999
Pages: 1160 - 1167
History
Received: Dec 29, 1998
Published online: Dec 1, 1999
Published in print: Dec 1999
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.