Stabilization/Solidification of High Mercury Wastes with Reactivated Carbon
Publication: Practice Periodical of Hazardous, Toxic, and Radioactive Waste Management
Volume 7, Issue 1
Abstract
This paper presents the study results for a novel stabilization/solidification (S/S) process for high mercury wastes (Hg >260 ppm). In this study, a low-cost powder reactivated carbon (PAC) was used to stabilize mercury in contaminated soils. Two types of contaminated soils were used: (1) a mercury-doped pure sand, used as a waste surrogate so as to minimize competitive adsorption by substances in real soils; and (2) a mercury-contaminated soil with about 2,300 ppm Hg from a mercury cell chlor-alkali plant. To improve the mercury adsorption capacity, PAC was impregnated with sulfides. It was found that sulfurized PAC significantly lowered mercury mobility. After stabilization, wastes were subjected to cement solidification. Results of toxicity characteristic leaching procedure and constant pH leaching tests showed that the S/S process successfully immobilized mercury in the treatment matrix. Even under attack from high chloride concentration, little mercury was leached from the matrix. Optimal S/S treatment parameters and treatment process flows are discussed for possible commercial implementation of the process. Based on the experimental data, it can be concluded that the S/S process by reactivated carbon and cement is a robust and effective technology for immobilization treatment of high mercury wastes.
Get full access to this article
View all available purchase options and get full access to this article.
References
American Public Health Association (APHA). (1998). Standard methods for the examination of water and wastewater, 20th Ed., Washington, D.C.
Carrot, P. J. M., Ribeiro-Carrott, M. M. L., and Nabais, J. M. V.(1998). “Influence of surface ionization on the adsorption of aqueous mercury chlorocomplexes by activated carbons.” Carbon, 36(1–2), 11–17.
Feick, G., Horne, R. A., and Yeaple, D.(1972). “Release of mercury from contaminated freshwater sediments by the runoff of road deicing salt.” Science, 175, 1142–1143.
Huggins, F. E., Huffman, G. P., Dunham, G. E., and Senior, C. L.(1999). “XAFS examination of mercury sorption on three activated carbons.” Energy Fuels, 13, 114–121.
Humenick, Jr., M. J., and Schnoor, J.(1974). “Improving mercury(II) removal by activated carbon.” J. Environ. Eng. Div. (Am. Soc. Civ. Eng.), 100(6), 1249–1262.
Gomez-Serrano, V., Macias-Garcia, A., Espinosa-Mansilla, A., and Valenzuela-Calahorro, C.(1998). “Adsorption of mercury, cadmium and lead from aqueous solution on heat-treated and sulphurized activated carbon.” Water Res., 32(1), 1–4.
Karatza, D., Lancia, A., Musmarra, D., and Zucchini, C.(2000). “Study of mercury adsorption and desorption on sulfur impregnated carbon.” Exp. Therm. Fluid Sci., 21, 150–155.
Liu, W., Vidic, R. D., and Brown, T. D.(1998). “Optimization of sulfur impregnation protocol for fixed-bed application of activated carbon-based sorbents for gas-phase mercury removal.” Environ. Sci. Technol., 32, 531–538.
Mohan, C., Gupta, V. K., Srivastava, S. K., and Chander, S.(2001). “Kinetics of mercury adsorption from wastewater using activated carbon derived from fertilizer waste.” Colloids and Surfaces A: Physicochemical and Engineering Aspects, 177, 169–181.
Namasivayam, C., and Kadirvelu, K.(1999). “Uptake of mercury(II) from wastewater by activated carbon from an unwanted agricultural solid by-product: coirpith.” Carbon, 37, 79–84.
Remy, H. (1956). Treatise on inorganic chemistry, Elsevier, Amsterdam, 464–472.
Sen, A. K., and De, A. K.(1987). “Adsorption of mercury(II) by coal fly ash.” Water Res., 21(8), 885–888.
Sinha, R. K., and Walker, P. L., Jr. (1972). “Removal of mercury by sulfurized carbons.” Carbon, 10, 754–756.
Schuster, E.(1991). “The behavior of mercury in the soil with special emphasis on complexation and adsorption processes—a review of the literature.” Water, Air, Soil Pollut., 56, 667–680.
Valenzuela-Calahorro, C., Macias-Garcia, A., Gomez-Serrano, V.(1990). “Study of sulfur introduction in activated carbon.” Carbon, 28(2–3), 321–335.
Wang, J. S., Huang, P. M., Liaw, W. K., and Hammer, U. T.(1991). “Kinetics of the desorption of mercury from selected freshwater sediments as influenced by chloride.” Water, Air, Soil Pollut., 56, 533–542.
Zhang, J., and Bishop, P. L. (2002a). “Stabilization/solidification treatment of mercury-containing waste using activated carbon/cement.” Proc., 3rd IWA World Water Congress, International Water Association, Melbourne, Australia.
Zhang, J., and Bishop, P. L. (2002b). “Solidification/stabilization of Hg(II)-containing solid wastes by cement after stabilization by sulfurized reactivated carbon.” Proc., 95th Air and Waste Management Association Annual Conf. and Exhibition, Baltimore.
Information & Authors
Information
Published In
Copyright
Copyright © 2003 American Society of Civil Engineers.
History
Received: Aug 20, 2002
Accepted: Sep 12, 2002
Published online: Dec 13, 2002
Published in print: Jan 2003
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.