Membrane as Solid/Liquid Separator and Air Diffuser in Bioreactor
Publication: Journal of Environmental Engineering
Volume 125, Issue 9
Abstract
A bench-scale pilot plant was operated to evaluate the potential of using microfiltration hollow fiber membrane modules as an air diffuser and solid/liquid separator in an alternate cycle within a bioreactor treating domestic wastewater. Two modules capable of air backwashing were immersed in a bioreactor. Compressed air backwashing and filtration by suction were effected alternatively. The experimental results reveal that application of the air backwashing technique to submerged membrane modules is capable of not only declogging the membranes but also of aerating the mixed liquor. Thus, better filtration flux rate and aeration without a separate aeration device were attained simultaneously. It was also noted that the introduction of an anoxic zone enhanced the removal of nitrogen. In addition, operation at low hydraulic retention time with high sludge concentration and the absence of a sedimentation tank indicate considerable savings on the plant area.
Get full access to this article
View all available purchase options and get full access to this article.
References
1.
Aya, H. (1994). “Modular membrane for self contained reuse systems.” Water Quality Int., (4), 21–22.
2.
Benítez, J., Rodríguez, A., and Malaver, R. (1995). “Stabilization and dewatering of wastewater using hollow fiber membranes.” Water Res., 29(10), 2281–2286.
3.
Chaize, S., and Huyard, A. (1991). “Membrane bioreactor on domestic wastewater treatment sludge production and modeling approach.” Water Sci. and Technol., 23, 1591–1600.
4.
Chiemchaisri, C., Wong, Y. K., Urase, T., and Yamamoto, K. (1992). “Organic stabilization and nitrogen removal in membrane separation bioreactor for domestic wastewater treatment.” Water Sci. and Techol., 25(10), 231–240.
5.
Chiemchaisri, C., and Yamamoto, K. (1993). “Biological nitrogen removal under low temperature in a membrane bioreactor.” Water Sci. and Technol., 28(10), 325–333.
6.
Fane, A. G., Fell, C. J. D., and Nor, M. T. (1978). “Wastewater treatment using a combined activated sludge and ultrafiltration system.” Proc., Asian Pacific Confederation of Chemical Engrg. (APCCHE), Jakarta, Indonesia, 117–129.
7.
Klopping, P. H., Marshall, R. H., Jr. and Richard, M. G. (1995). Activated sludge operations for pulp and paper mills. Callan Brooks Publishing, Corvallis, Ore.
8.
Li, A., Kothari, D., and Corrado, J. J. (1984). “Application of membrane anaerobic reactor system for the treatment of industrial wastewater.” Proc., 24th Annu. Purdue Industrial Waste Conf., Purdue University, West Lafayette, Ind., 627–636.
9.
Lübbecke, S., Vogelpohl, A., and Dewjanin, W. (1995). “Wastewater treatment in a biological high-performance system with high biomass concentration.” Water Res., 29(3), 793–802.
10.
Maythanukhraw, R. ( 1995). “Application of air backflushing technique in membrane bioreactor,” MS thesis, Asian Institute of Technology, Bangkok, Thailand.
11.
Morris, G., and Bird, P. ( 1994). “The EC urban wastewater treatment directive and the removal of nutrients.” Nutrient removal from wastewaters, Horam et al., eds., Technomic Publishing, Lancaster, Pa.
12.
Muller, E. B., and Stouthamer, A. H., Van Verseveld, H. W., and Eikelboom, D. H. (1995). “Aerobic domestic wastewater treatment in a pilot plant with complete sludge retention by cross-flow filtration.” Water Res., 29(4), 1179–1189.
13.
Rittmann, B. E. (1987). “Aerobic biological treatment.” Envir. Sci. and Technol., 21(2), 128–136.
14.
Sawyer, C. N., McCarty, P. L., and Parkin, G. F. (1994). Chemistry for environmental engineering. McGraw-Hill, New York.
15.
Sewerage in Japan—Its status and plans. (1993). Japan Sewage Works Association, Tokyo, Japan.
16.
Shimuzu, Y., Matsushita, K., Shimodera, K., and Watanabe, A. ( 1992). “Shear breakage of bacterial cells with crossflow filtration.” Biochemical engineering for 2001, S. Furusaki, I. Endo, and R. Matsuno, eds., Springer, Tokyo, 578–580.
17.
Smith, C. W., Di Gregorio, D., and Talcott, R. M. (1969). “The use of ultrafiltration membrane for activated sludge separation.” Proc., 24th Annu. Purdue Industrial Waste Conf., Purdue University, West Lafayette, Ind., 1300–1310.
18.
Standard methods for the examination of water and wastewater. (1989). 17th Ed., American Public Health Association, American Water Works Association and Water Pollution Control Federation, Washington, D.C.
19.
Suwa, Y., Yamaguchi, T., Urushigawa, Y., and Hirai, M. (1989). “Simultaneous organic carbon removal—Nitrification by an activated sludge process with cross-flow filtration.” J. Ferment. Bioengrg., 67, 119–125.
20.
Trouve, E., Urabin, V., and Manem, J. (1994). “Treatment of municipal wastewater by a membrane bioreactor: Results of a semi-industrial pilot-scale study.” Water Sci. and Techol., 30(4), 151–157.
21.
Yamamoto, K., Hiasa, H., Talat, M., and Matsuo, T. (1989). “Direct solid liquid separation using hollow fiber membranes in an activated sludge aeration tank.” Water Sci. and Technol., 21, 43–54.
22.
Yokomizo, T. (1994). “Ultrafiltration membrane technology for regeneration of building wastewater for reuse.” Desalination, 98, 319–326.
Information & Authors
Information
Published In
History
Received: Dec 9, 1997
Published online: Sep 1, 1999
Published in print: Sep 1999
Authors
Metrics & Citations
Metrics
Citations
Download citation
If you have the appropriate software installed, you can download article citation data to the citation manager of your choice. Simply select your manager software from the list below and click Download.